Polaris ATV Forum
Go Back   Polaris ATV Forum > Polaris ATV Technical Discussions > ATV Repair and Maintenance

ATV Repair and Maintenance Having problems? Doing a rebuild? All Repair/Maintenance Discussions here.

Reply
 
LinkBack Thread Tools Display Modes
  #1 (permalink)  
Old 03-20-2011, 07:56 AM
cliffstone's Avatar
Junior Member
 
Member #13112
Join Date: Mar 2011
Location: new mexico
Posts: 3
Air cool system fan stuck on??

2007 polaris trailboss 330 fan motor will not shut off unless battery disconnected. After motor started red overheat light immediately comes on. Need help please
Reply With Quote
Sponsored Links
PolarisATVForums is the premier Polaris ATV Forum on the internet. Registered Users do not see these ads, So Register, It's Free!
  #2 (permalink)  
Old 03-20-2011, 08:58 AM
chembrew's Avatar
Junior Member
 
Member #12954
Join Date: Mar 2011
Location: Northern NJ
Posts: 23
sounds like the fan is just doing what it is told. If the hot light comes on immediately even when the engine is cold, then it sounds like the engine temp sensor has failed, or the "same" wiring is chaffed or shorted. If you unplug the temp sensor on the harness, see if the fan goes off.
Reply With Quote
  #3 (permalink)  
Old 03-20-2011, 09:10 AM
cliffstone's Avatar
Junior Member
 
Member #13112
Join Date: Mar 2011
Location: new mexico
Posts: 3
Thanks, tried unplugging temp sensor, fan still on. Not sure whats going on unless I'm unplugging wrong wire.
Reply With Quote
  #4 (permalink)  
Old 03-20-2011, 09:34 AM
cliffstone's Avatar
Junior Member
 
Member #13112
Join Date: Mar 2011
Location: new mexico
Posts: 3
probably should have mentioned after shutting down the motor (power switch and key out) fan continues to run indefinetly until i disconnect the battery cable
Reply With Quote
  #5 (permalink)  
Old 03-21-2011, 07:16 AM
chembrew's Avatar
Junior Member
 
Member #12954
Join Date: Mar 2011
Location: Northern NJ
Posts: 23
Typically, there is fuse and then a fan "relay" in series that can power and feedback the fan sensor and can power the fan itself and should only be powered or activated with "key on" in ignition run. If that relay circuit or the associated harness point is shorted, then it could send power out all the time and I presume also indicates a hot temp light on the computer (fan on - indicator on). The relay can be changed like a large fuse. disconnect batt - Pull the relay - connect batt, fan should remain off. If the fan stays on there is a short in the harness somewhere else. Next disconnect the batt again - replace old relay with a new relay and see if this corrects the problem.
Reply With Quote
  #6 (permalink)  
Old 03-21-2011, 11:43 PM
gradykraft's Avatar
ATV Enthusiast
 
Member #4002
Join Date: Mar 2010
Posts: 30
I had a 2007 Sportsman 450 that did the same thing. I ended up replacing the ECM.
Reply With Quote
  #7 (permalink)  
Old 03-22-2011, 08:11 AM
Hit.The.Gas's Avatar
Extreme ATV Enthusiast
 
Member #11694
Join Date: Feb 2011
Location: OHIO
Posts: 173
The hot light and fan switch are both built into the controller module under the front hood. This is very likely the problem. If I was working on it, I would order this part before I even took a look at it, it's a typical problem. OEM number 4011831, I can get you one for $179.07, let me know. ~Phil
Reply With Quote
  #8 (permalink)  
Old 09-03-2013, 05:10 PM
lilgoalielvr's Avatar
Junior Member
 
Member #38558
Join Date: Sep 2013
Posts: 1
Cool 4011831 controller-module

Phil
I need a controller-module for my 2008 Polaris Trail Blazer 330. Can you still get them and if so what would the cost be? Thank You
Reply With Quote
Reply

Lower Navigation
Go Back   Polaris ATV Forum > Polaris ATV Technical Discussions > ATV Repair and Maintenance


Search tags for this page

08 polaris trailblazer 330 cooling fan runs all the time

,
2007 330 trail boss temp switch
,
2007 polaris sportsman says hot and fan runs all the time with key off
,
2007 polaris trail boss 330 ecm
,
2007 polaris trail boss 330 fan runs constantly
,
2007 trail boss 330 fan stays on
,
2009 polaris trailblazer 330 fan wont shut off
,

4011831 polaris

,
polaris trail boss 330 fan stays running constantly
,
trail boss 330 fan stays on
,
why does cooling fan on a 330 polaris atv keep running when switch off
,
why does my polaris 330 cooling fan stay on
Click on a term to search our sites for related topics.

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
2007 500 X2 radiator fan runs but not enough to cool 500x2 ATV Repair and Maintenance 22 03-30-2011 04:14 PM
Big Gun ECO system? jackstrx ATV Performance Modifications 7 01-31-2011 07:24 AM
System 6's on your xp? MNPolaris850XPeps Polaris XP 0 01-27-2011 10:55 AM
500 EFI Plow System eclifford634 Polaris Sportsman 7 12-09-2010 08:21 AM
Starting system on 00 500 JoshH Polaris Sportsman 3 08-14-2010 05:38 PM

Motosport.com


All times are GMT -8. The time now is 11:36 AM.


Powered by vBulletin® Version 3.8.7
Copyright ©2000 - 2014, vBulletin Solutions, Inc.