Polaris ATV Forum banner

Search results

1-20 of 199 Results
Advanced Search
  1. 2008 Polaris Sportsman 300 Engine Removal- Is it Integrated

    ATV Repair and Maintenance
    Yes - the engine and transmission are removed as a unit and then the engine is removed from the transmission I have the 2009 300 service manual in PDF and can email it to you - just PM me your email address I should mention; the 2008 manual #9921340 covers only the 2008 300 - the 2009 manual I...
  2. Weak spark

    Polaris Sportsman
    Set it on the highest DC volt scale and crank the engine - if the reading is point something, then click down a scale - when the reading exceeds the scale selected, go up to the next scale and read the voltage displayed.
  3. We Are Live - Community Feedback

    Community Help
    All right! :deadhorse: (n) :dito: (n)
  4. 2004 magnum 330 service manual

    Polaris Magnum
    Sent it to you
  5. Vin number on 96 magnum

    ATV General Discussion
    7072791 is the part number for the air filter decal - NO LONGER AVAILABLE for purchase - was used on various 89-2000 models. None of the other numbers come up as a part or VIN What state are you in? Check with the DMV and use the legal process to obtain a title and registration. Why do you...
  6. Vin number on 96 magnum

    ATV General Discussion
    Here's the info on you machine: Model Name - MAGNUM 2X4 Model Year - 1996 Model Number - W967544 Purchase Date - 10/9/1996 VIN - 2931635 Engine Serial Number - 9609644 Warranty Factory Warranty Start Date - 11/4/1996 Expiration Date - 4/9/1997
  7. 2000 Xpedition 325 shift lever

    Polaris Xplorer and Xpedition
    If the spring is broke - usually the spring stays captive to the shaft - if one leg of the spring breaks and falls free, it usually just lays on the crankcase floor and doesn't cause any problems, but it is on a design by design case. In one engine the part can't move around due to the shape of...
  8. Sportsman 700 no spark

    Polaris Sportsman
    Typically the voltage to the coil will be about 100 volts peak - must be measured with a peak voltage tester or oscilloscope
  9. 2013 Polaris Phoenix 200 rear clutch removal

    ATV Repair and Maintenance
    You should use 38 mm or 1.5 inch socket
  10. Sportsman 90 trans poping

    Polaris Sportsman
    I just don't know without being there or having the machine available. An off the cuff guess - the chain is too tight - when the chain is over tight and you get on it, it becomes even tighter - the chain should be adjusted for about 3/4" of play halfway between the sprockets when the axle...
  11. Sportsman 90 trans poping

    Polaris Sportsman
    Any chance the chain is just too tight?
  12. 2008 polaris sportsman 500 idle/ cold start issues

    Polaris Sportsman
    Did you get the 500HO with carburetor or fuel injection? What is the VIN?
  13. We Are Live - Community Feedback

    Community Help
    Any chance of getting the GIF smilies back?
  14. 2009 Sportsman 500 HO

    Polaris Sportsman
    Doctor Frankenstein LIVES! :eek:
  15. 2008 500 HO carb model. Getting the flashing HOT on the gauge?

    Polaris Sportsman
    A Few drops of coolant could just have been spillage from the servicing. Just keep an eye on the coolant recovery bottle and keep the coolant level at the low mark when the engine is cold.
  16. What brand bearing axel seal

    ATV General Discussion
    That part number is for the bearing which is an industry common DAC44720033 dual row angular contact ball bearing with integral seal. Get them from Polaris, All Balls, Quad Sport, Amazon or Ebay
  17. No oil, ... is there a specific type of damage this will do to the engine?

    ATV New Members
    Running out of oil is never good and the top end of the engine suffers the most - if the crankshaft is roller bearing, it probably was not hurt - if the crankshaft main or rod bearing is a plain bearing, I would advise running it til it quits and install a new or rebuilt motor or you could have...
  18. 2009 Sportsman 500 HO

    Polaris Sportsman
    The upper half of the headlight pod (5436819-498) was the same for the following models: 2008 SPORTSMAN 500 HO (A08MH50AX/AZ) - Body, Headlight Pod 2008 SPORTSMAN 500 HO EFI (A08MN50AF/AN/AQ/AR/AS/AT/AW/AX) - Body, Headlight Pod 2008 SPORTSMAN 6X6 (A08CL50AA) - Body, Headlight Pod 2009...
  19. 2000 Xpedition 325 shift lever

    Polaris Xplorer and Xpedition
    Here's how to figure out what is happening: If the shift lever has no resistance to movement and seemingly stays 'down' the spring might be broken - normally is the spring breaks, the transmission will up shift fine, but to down shift the lever has to be raised about 1/2 of it's full travel...
  20. 2013 Polaris Phoenix 200 rear clutch removal

    ATV Repair and Maintenance
    No and I don't have one to measure - it's metric, but over 19mm you can usually find an inch socket that will work - 19mm is an almost perfect 3/4 - 5/16 and 8mm are interchangeable as is 7/16 and 11mm - a 14mm is a loose 9/16" - 13mm is a real loose 1/2" (a 6 point 13mm can be used for a 1/2"...
1-20 of 199 Results
Top