Polaris ATV Forum banner

2005

  1. 2005 Polaris Sportsman 400 completely dead after rough start

    ATV Repair and Maintenance
    Hey all, Long time lurker, rare poster here. I need some assistance. I'm having a heck of a weekend with my ATV. First, I went for a 10 mile ride with a wasp nest between my legs (they built it under the wheel well) and was wondering why I was getting swarmed every time I stopped or slowed...
  2. 2005 Sportsman 500 HO Sputtering at 3500 rpm?

    ATV Repair and Maintenance
    I have a 2005 Sportsman 500 HO that has begun sputtering at around 3500 rpm only. It sputters like a rev limiter at 3500 Accelerating or decellerating. I have a spare parts bike and have swapped both modules rebuilt the carb, changed the plug and run 10 gallons of fresh gas through it. Any ideas...
  3. New here. Need Predator 50 manual

    ATV New Members
    New to this site. I just acquired two identical 2005 Predator 50 cc machines for my twin grandsons. They haven't been started for 4 years and I am about to dive into them. I am in search of a maintenance manual. Any help would be greatly appreciated!
  4. Radiator/ snorkel kit for 05 sportsman 800 twin efi

    ATV Performance Modifications
    Looking to relocate my radaiator and add a snorkel kit to my 05 sportsman 800 twin efi. Any suggestions would be great. Thanks
  5. 05 ranger clutch & exhaust

    ATV Repair and Maintenance
    Are there aftermarket clutches available for a 2005 Ranger 500 . Mine is shot out and before I replace with a stock clutch want to see what's available . I need a new exhaust also .
  6. 05 500 predator won't start, electrical

    Polaris Predator
    I have a 2005 predator and it all of a sudden won't start. I can push/pull start it but my starter solenoid keeps clicking. I put a new solenoid in it and it still keeps clicking. Once in a great while it will barely turn over. HELP????
  7. 2005 Sportsman 90 Question

    Polaris Sportsman
    Hi , Im new to this fourm, I picked up a 90 for my 6 yr old son He loves it ! when I got it it needed some new plastics, iefront grill and right fender flairs. and front rack. Dose anybody Know , What years Interchange plastics ?? Thank you in advance ! J
  8. 2005 Sportsman 90 Question

    Polaris Sportsman
    Hi , Im new to this fourm, I picked up a 90 for my 6 yr old son He loves it ! When I got it it needed some new plastics, IE: Front grill and right fender flairs. Dose anybody Know , What years Interchange plastics ?? Thank you in advance ! J
  9. 2005 ATP 330 rear not locking

    ATV Repair and Maintenance
    Hi all, newbie here. I have a 2005 ATP 330 which has the on demand AWD. The diagnostic shows "off" when in 2x4 and "on" in AWD. In 2x4 and AWD the rear is not locking. I'm getting 12 volts at solenoid but no lockup. Any ideas? Thanks
  10. For Sale: 2005 predator and spare parts bike

    ATVs For Sale
    I'm thinking about selling my predator, it's been a good, strong bike. Im Just thinking about getting something alittle newer... Maybe a stock outlaw 525s. Nothing is wrong with the bike. Just got a new timing chain, new rings and the valves checked and adjusted. The bike runs strong and...
  11. Gas in oil - '05 Sportsman 700

    ATV Repair and Maintenance
    Having a problem where my Sportsman 700 (not EFI) will not run unless choked. So as I'm troubleshooting, I check the oil just to be thorough. It looks too thin and when I sniffed it, it smelled like gas. I had the dealership fix a problem like this a couple years ago. What causes this and what...
  12. 2005 Magnum 330 4-wheel drive issue..

    ATV Repair and Maintenance
    So I recently purchased a 2005 Polaris Magnum 330 4x4 and took it out that same day with no issues. It was rode hard for the weekend and when returned, and serviced I began to notice a lot of issues. Main thing I cannot seem to figure out is the 4 wheel drive engagement. At first glance when...
  13. Motor swap out question - will 2007 fit in 2005 chassis?

    ATV Repair and Maintenance
    We have a 2004 Sportsman 500 HO that needs a new engine. Have found one from a 2007 Sportsman 500 HO, but wondering if it will fit in the 2004 chassis. Any input would be appreciated.
  14. Fuel Gauge shows 1/2 full all the time-HELP NEEDED !!

    Polaris Sportsman
    no matter how much gas is in my 500 sportsman the gauge shows half full:werd:
  15. 2005 Polaris predator 500 Video

    ATV Media
    Hi guys. this is a video me and my friend made for a little fun. i directed and filmed,he rode and looked awesome. please tell us what you think of it! 2005 Predator 500/ Breaking Benjamin: Blow me away - YouTube
  16. 05 predator wont start!!!!!

    Polaris Predator
    I have been working on my pred for a while now, I let it sit for about two weeks after i changed the oil and filter, before I tryed to start it I found the battery to be dead so I charged it and tryed to start it again. When I clicked the starter button all I herd was a little ticking down by...
  17. 05 Sportman 800 EFI Not Locking into 4 wheel

    Polaris Sportsman
    Hello..... I have a 05 Sportman 800 EFI that is not locking into 4 wheel drive. When the 2 x 2 to 4 x 4 switch is activated the gauge will show the 4 wheels as in 4 wheel drive however the front wheels will not engage. Whether in High or low gear. I placed the machine on blocks engaged the...
  18. New Plastic

    Polaris Sportsman
    Hey everyone, I have a 2005 Sportsman 500 HO. It is blue and I would like to change my plastic out to green or camo. I've been looking online for places that would cary plastic bodies but have been unable to find anything other than some ebay auctions that had bodies but not what I was...
  19. 2005 Sportsman 500 submerged

    Polaris Sportsman
    I have an 05 sportsman 500 that I had the unfortunate problem of falling into a deep hole in a creek. Needless to say it was submerged for about a half hour. After we got it back on the bank I pulled the plug and turned it over to get any water out of the cyclinder. I have drained the water...
Top