Polaris ATV Forum banner


  1. 07 sportsman efi fan problems please help!!!

    Polaris Sportsman
    I got a 07 sportsman efi the fan comes on when it wants to not when it should which cause me to over heat at slow speeds and I got to turn the key x5 to the on position to get the fan to turn on I got a new thermister when I unplug it the fan runs I swapped the relays nothing I jumped the relay...
  2. Vacuum Not Working Properly?!?!

    ATV Repair and Maintenance
    Hey guys, I have a 2007 Polaris Scrambler 500 4x4 and I don't think that the vauum is working properly. I thought it was the fuel pump, but it still didn't start after I replaced the fuel pump. I also replaced the carb before because it was broken. The 2 wires that go to the fuel pump I thought...
  3. Speedometer Problems Sportsman 450

    ATV Repair and Maintenance
    Hello all, I'm new to the forums. I have a 2007 Sportsman 450 that I just picked up that doesn't show the correct speed. The guy I bought it from installed a brand new speed sensor and I even checked all the connections upon bringing it home. When I hammer on it and get going pretty good the...
  4. New member needs help - 2007 Sportsman 500 EFI AWD issue

    ATV New Members
    2007 Sportsman 500 H.O. EFI AWD symbol showing in Low gear and Reverse only - do not get AWD symbol in H gear. H gear symbol does not show up at all actually in either 2WD or AWD on Cluster and no AWD symbol when in H gear. Advice? Why would it work properly in all other gears but H gear...
  5. 2007 Sportsman 700 EFI twin Crankshaft

    ATV Parts Wanted
    In need of a crank shaft for a 2007 Sportsman 700 EFI twin can be used.
  6. 2006 / 2007 Polaris Sawtooth Kickstart

    ATV Parts Wanted
    Hello. I am looking for the kickstart "assembly?" (pedal plus arm to spindle) for either a 2006 or 2007 Polaris Sawtooth ATV. Thanks.
  7. polaris outlaw 2007

    ATV Repair and Maintenance
    Is it normal that i can only start it in neutral? If not what can be the problem? Thanks
  8. '07 Sportsman 500 HO X2 maintenance needs

    Polaris Sportsman
    hi fellow wheelers I've got an '07 500 X2 with about 1400 miles on it & close to 168 hours. mainly use this for plowing in the winter and trail ridding in the summer. we ride pretty hard on the trail mix of mud/rock/dirt with some bush whacking/new trail or linking trails together. all I've...
  9. 07 sportsman 500 efi need serious.help?

    ATV Repair and Maintenance
    Got ATV week ago ran fine all week with wife and I riding around. Had a few issues when I traded dirtbike for it. Pull start gone, air box tab broke so ordered new air box and recoil housing and installed. Decided to go ride by myself today. Ride a bit hard for 1/2 hour went down a big hill...
  10. 2007 TB 330 - Service and Information Help

    Polaris Trail Boss
    I bought 6 (Yes, 6) 2007 Polaris 330 Trail Bosses. They were used for a guided tours business but had been sitting in a storage facility lot for about 2 years. I already have the seats being replaced. Plastics are still good. I also have the service side of things covered as far as changing...
  11. Motor swap out question - will 2007 fit in 2005 chassis?

    ATV Repair and Maintenance
    We have a 2004 Sportsman 500 HO that needs a new engine. Have found one from a 2007 Sportsman 500 HO, but wondering if it will fit in the 2004 chassis. Any input would be appreciated.
  12. 03 headers in 07 predator 500

    ATV General Discussion
    I found an aftermarket header that came from an 03 predator 500, the seller says that it will also fit my 07. Does anyone know if this is true? 03 header can be placed in an 07? Thanks!
  13. 2007 Sportsman 700 Fuel Map???

    Polaris Sportsman
    I have a 2007 Sportsman 700 with full exhaust, K&N filter, 27 inch tires, lifted, re-clutched etc... Bought a Power Commander III usb to re-map after I put on the exhaust and noticed when using the only map I could find for an '06 sportsman my y-pipe GLOWS CHERRY as about the pipe through the...