Polaris ATV Forum banner

450

  1. Sportsman 450 carburator question

    Polaris Sportsman
    I just purchased a 07 sportsman 450 that is having carburetor issues. When I started going through the carb I found that the previous owner had glued a hardware bolt into a hole located on the right side as you can see in the image. I got the bolt out and it looks like it should be just a...
  2. Speedometer Problems Sportsman 450

    ATV Repair and Maintenance
    Hello all, I'm new to the forums. I have a 2007 Sportsman 450 that I just picked up that doesn't show the correct speed. The guy I bought it from installed a brand new speed sensor and I even checked all the connections upon bringing it home. When I hammer on it and get going pretty good the...
  3. Electrical Issues 06 Sportsman 450

    ATV Repair and Maintenance
    Great forum - have gleamed a lot of good information. I have search the forums and found similar problems, but my main question is ohm reading on the stator. My cluster stated flashing the battery and would go out after riding at a steady speed. My RPMs are not registering but the other items...
  4. Sportsman 450 ho mods?

    Polaris Sportsman
    Hey there I just picked up a 2016 450 ho and so far I like it but it's not in my nature to leave things stock, don't wanna go to crazy but just wondering what kind of after market things are available for this thing
  5. Outlaw runs, but loses spark after about 5 min.

    Polaris Outlaw
    Hey, I have a 2008 outlaw 450 mxr, it runs like a champ for 5-10 minutes, but once it is hot it loses spark, and won't start again until its cooled off. I'm not 100% sure what the problem is but I suspect its the stator. Any advise, or help would be greatly appreciated.
  6. Valve pulled through the valve spring

    ATV Repair and Maintenance
    I am wondering if a dirty air filter can cause the valve to get pulled through the valve spring. I am currently in a situation where the top end was rebuilt and about 2 rides later the valve was pulled through the valve spring. The bike is under warranty and the inspector denied coverage stating...
  7. General tune up

    ATV Repair and Maintenance
    Hey guys, doing a tune up on my 06 sportsman 450 this weekend. I'm planning on cleaning the carb, cleaning the air filter, new spark plug, change the oil, and change the fuel filter. Anyone else have any other recommendations? Can anyone recommend a good plug? And anyone use oil other than the...
  8. 06-11 Outlaw and Predator Parts

    ATV Parts for Sale
    Here's what I have - Make me an offer, I would love to sell it all together or by model. All great condition. Polaris Outlaw 450, 500 and 525 Parts 1. Rear Rock Guard – Part No. 5436463 – Fits 06-07 Outlaw 500, 07-11 Outlaw 525 - 2. Fuel Tank – Part No. 2520711 – Fits 07-08 Outlaw 525, 08...
  9. Rad Relocate for 07' 450 Sportsman???

    Polaris Sportsman
    Hey guys, ive got a question. Ive got an 07' Sportsman 450 that im lookin to relocate the rad. Im tired of after a good mud trip tryin to clean the dam rad out... its in the dumbest place. Im wantin to relocate it ontop of the front rack. I haunestly don't care for the front rack on my machine...
  10. 2006 Sportsman 450 died first time out

    ATV New Members
    Hi, I am new to this forum. I just bought a 2006 Sportsman 450 and on my first trail ride today it died on me. The engine just stopped running suddenly and the instrument display went blank. The starter won't crank the engine and the instrument display is not turning on at all. The headlights...
  11. Sportsman 450 500 700 800 rear outboard CV Joint Kit Outer Rear 06-07

    ATV Parts for Sale
    Hi, selling this on ebay for $68: Polaris Sportsman 450 500 700 800 Rear Outboard CV Joint Kit Outer Rear 06 07 | eBay This CV joint will fit the following POLARIS Sportsman 4x4 applications: 450 Sportsman 4x4 06-07 500 Sportsman EFI 4x4 06-07 500 Sportsman HO 4x4 06 500 Sportsman X2 4x4...
  12. HELP! 06 Sportsman 450 wont charge

    Polaris Sportsman
    I have a 06 sportsman 450. I just did a complete rebuild, new jug, new piston, cleaned valves, rebuilt bottom end so i'm pretty excited to ride it. Only problem is that it wont charge itself, Once the battery is drained from just running the fan and lights the quad shuts off, not even the pull...
  13. 2006 sportsman 450 fuel?

    Polaris Sportsman
    Hey I am a new registry. I currently need some advice. I have a 2006 sportsman 450 that will crank and idle on choke (will not run without) and will go dead when you push the accelerator. Any ideas would be very helpful or if you had similar problems.
  14. Movie WCRTeam production polaris MXR 450

    ATV Media
    ADD - Wreck Crew Racing - on facebook. ADD - Wreck Crew Racing - on facebook. ADD - Wreck Crew Racing - on facebook. Compillation outlaw Mxr 450, exhaust motoworks sand pit polaris outlaw 450 mxr Sand pit with outlaw 450 et kfx 450 WCRTeam compillation this summer MX track WCRteam:top:
  15. looking for outlaw 450 or 525

    Polaris Outlaw
    I am selling blue nose pitbull puppies for 1100, if anyone is thinking of getting rid of their outlaws id be willing to give you a free pup of your choice and a brand spanking new 17" red dell laptop with a blu ray player built in that i just got for a christmas gift if interested let me know...
  16. 08 outlaw mxr

    Polaris Outlaw
    hey guys, new to the site here, i joined hoping to learn some stuff here and there.. I have a question, how are you guys loading your mxr? if im correct some of the older polaris cant be stood up cuz of oil going somewhere and causing a problem?.. My question is can I load my mxr standing up?
  17. crossing stream problem

    Polaris Outlaw
    has anybody had any problems while crossing stream/rivers? I have a 08 450mxr and we headed to the mountains crossed a couple streams maybe 1.5' deep or so at first it was fine, turned the bike off and when i tried to restart it would just crank like it had no spark. on the way back it would...
  18. 06 sportsman 450 brake problems

    ATV Brakes & Suspension
    I have an 06 sportsman 450 with brake problems. I have put new fluid in, bled the lines, put on new brake lines and new pads and still the front brake handle has no pressure in it. Could there be something wrong with the master cylinder itself? Mine has a little "window" on the top of the cap...
Top