Polaris ATV Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 84 Results
  1. Polaris Sportsman 570
    I have a 2015 Sportsman 570. I put a 2" lift and 30' mayhems on it. I've replaced the rear axles 8 + times due to the boot rubbing up against the control arm bracket bolt. I've tried most of the cheaper axles and it seems like the boot is just too big for the bracket space. Has anyone else had...
  2. ATV Repair and Maintenance
    Hi all, I know there is a few forums already on Ranger 570 knocking sound. have taken top off engine, cranked engine around with drive belt. the exhaust side, drivers side valve seems the problem. Just as the tappet seems to be at the top, then dropping down again it pops back up hitting the cam...
  3. Polaris Sportsman
    ATV: 2024 Sportsman 570 Trails less than 100 miles. Story: Cruising through riverbed with super soft muddy surface I attempted to cross and it was shallow, I could see the bottom, instantly sank to skid plate submersing ATV up to the seat. I haven’t ridden a quad in a very long time and didn’t...
  4. Polaris Sportsman 570
    Hey all brand new here. I’m looking for wiring diagrams for a 2023 sportsman. My fist quad and im looking to add accessories but I want to wire them up correctly. Any help with the diagrams would be greatly appreciated. thanks
  5. Polaris Sportsman
    Newbie here, I have a 2015 Sportsman 570 that died while idling and will not start now. I have a new battery and it is charged and it still doing the same thing the starter will engage but not turnover. If I take the spark plug out it will turnover no problem. Is this a starter going bad or is...
  6. Polaris Sportsman 570
    Hi folks. Recently bought a 2015 Sportsman 570 Touring. Condition is very good, looks like a newer machine. Have probably put an hour on it. I used it for some work around the yard on Sunday, and was sitting idling about to go for a ride when the engine stopped and the check engine light came...
  7. ATV Performance Modifications
    Changed out my old grips with new ProGrip today on my 570 X2
  8. ATV Performance Modifications
    Hello everyone, I have a question about the REV override button on my Sportsman 570, eps t3b, 2022 Europe. As far as I know, when I press the button, the rev limiter should switch off and I have full power in 4WD in reverse gear. Unfortunately, but nothing happens, instead I can switch with the...
  9. ATV Purchasing and Price
    I need an ATV with good utility potential. Deep mud is rare and generally avoided so, if I get muddy it is because I made an error in judgement in the pasture! I live in East Texas so, the ground is generally sandy and wet. I pull downed tree limbs with my tractor right now but, want to use...
  10. ATV Repair and Maintenance
    2015 Sportsman 570 SP, with EPS. Started fine, drove it down the road 1/2 mile, and while i was opening up the gate, it shut off and there is no power. I wiggled the battery connections, kill switch, checked for mice damage, etc., and found nothing. I didn't see any blown fuses but it started...
  11. ATV Repair and Maintenance
    I was waiting to post on the forum, but I'm thoroughly stumped. So here's the full story: Got a 2016 Sportsman 570 from a guy who put a rev6 bottom end in it because pickup tube came off. Says he couldn't figure out timing. So we take it apart, set the timing, and had no compression. Took off...
  12. Polaris Sportsman 570
    2014 polaris sportsman 570 efi, got my atv out to warm it up after sitting a few months. Has Gass and a full charge on the battery. Started it with only a little trouble. It had been a while. Ran it for about 5min on idle and it shut off. Now the starter turns it over but the engine does...
  13. Polaris Sportsman 570
    I finally got to the dyno Dec. 2nd. The sportsman 570 rated at 44 crank horsepower puts down 33 wheel horse power. My only mods are snorkel kit and QSC clutch kit. I tried a K&N air filter first, it made less than 1 horsepower difference. I also tried a iridium spark plug(found the part...
  14. ATV Repair and Maintenance
    '14 570 EFI. When you press the throttle beyond ½ way, the motor bogs down over and over. There was a large hole in the mid-pipe right at the exit of the elbow. I've had to use it to get to the end of the season, but now it's acting up. Wondering if one could have to do with the other or what...
  15. ATV Repair and Maintenance
    On a ranger 570 can you replace the cylinder barrel(I guess thats what you call it) without splitting the case?
  16. ATV Repair and Maintenance
    I have a practically brand new 570 with zero mods that keeps killing the battery. I have replaced the battery 3 times this winter. If the bike sits up for more than a couple of weeks the battery is so dead that it will not charge and the bike doesn’t start. After riding the bike is parked with...
  17. Polaris ATV News
    I just ordered a 2021 Sportsman 570 Premium in titanium on April 27. Wondering if anyone out there has ordered one recently and what their wait time was or what they were told it would be for a that model or one similar. Also I am located in Northeastern PA, Thanks!
  18. ATV Repair and Maintenance
    Hi, Been using my ATV over winter here, but it had been standing a few days now (key out), I was going out to start it to move it into garage for replacing the track with wheels. And it was completely dead, as in no power to instrument panel or anything. (And no, the stop switch isn't pushed...
  19. Polaris Sportsman 570
    I know I know, take it to the dealer, but if it's something simple I'd like to avoid the hassle. I have a '21 570 EFI, and for some reason it bogs down/sounds like it's not getting enough spark or fuel, or something I'm unaware of. It was doing it a little when riding around 4800 rpms, and now...
  20. Polaris Sportsman 570
    So I am looking for some new rear axles for my 2021 570 non sp. I’m wondering if the 2020 east lake rear axles will fit a 2021? I’m currently running outlaw 2s 29 1/2 and need new axles due to breaking both rear axles. Any help is appreciated.
1-20 of 84 Results
Top