Polaris ATV Forum banner
awd not working
1-8 of 8 Results
  1. ATV Repair and Maintenance
    Hey everyone, As I'm sure is easily noted, I'm new to the forum, and the Polaris world in general. I recently purchased a used 2006 Sportsman 500 HO EFI; this thing is awesome and has stood up to literally everything I've thrown at her. However, during a recent excursion to Busco Beach, a...
  2. ATV Repair and Maintenance
    05 sportsman 700 twin. AWD isn't working. I have a service manual and have gone thru everything. feel free to ask questions on specifics. Brown w/ white wire coming from 16 pin connector behind instrument cluster, i have no power here. this is the wire that controls the coil down in the...
  3. Polaris Sportsman
    Ok I'm new here so I'll try and explain it as best as possible. I have a 2002 sportsman 700 twin and my AWD won't engage. I have put it in the air and tried it and nothing. The light goes on and says it is on but it does not engage. I had it engage one time when I was stuck I kept rocking in...
  4. Polaris Sportsman
    I have a 1996 400 sportsman and the headlights aren't working. Low or high. 4wd stopped working and the electric start stopped working. I replaces atheist start button and headlight switch and tge headlights worked for a couple seconds but went out again and the push button 4x4 has been replaced...
  5. Polaris Magnum
    If you put it in reverse and hit the override button it works fine. It will work in high and low if you hold the shifter up. You can get it to stay on but if you jar it the smallest bit it cuts off. I checked to see if I could correct it with the shifter linkage but no go. There is a smal amount...
  6. ATV Repair and Maintenance
    I have an 04 polaris sportsman and the 4x4 does not work. The drive shaft is turning to the front and to the wheel but the hilliard clutch will not engage. I put it up on a lift and put it in gear at high RPM then checked for voltage on the wires that go down to the strut tower where the coil...
  7. ATV New Members
    Hello everyone, I am new to the forum. I have a 2000 Polaris AWD that is intermittently going out of AWD. If I turn the wheels to the right the AWD will kick in and if I turn it to the left it will kick out. I can't find any visual problems with the wirirng at all . Has anyone ran into this before?
  8. ATV Repair and Maintenance
    Have you lost your spedo/cluster power, lost your AWD and your Highbeam, well here is the probable fix. I have written this twice and fixed a few Polaris with the exact problems including my 2004 Sportsman 500HO and the Departments 2006 Sportsman 700 and a few of my friends Polaris ATV's. So I...
1-8 of 8 Results
Top