Polaris ATV Forum banner

boss

  1. Too much positive camber?

    Polaris Trail Boss
    Hello all, I am new to the forums! I just bought my trail boss a few weeks ago. I noticed the left side wheel has quite a bit of camber, it almost seems like more the the right side. But are these wheels suppose to have this much lean out on the top of the tire? Or is there something bent...
  2. trailboss 250 wont start

    ATV Repair and Maintenance
    i have a 1991 trailboss 250 has good compression gets good spark, gets fuel, but it wont do anything but hit, i have sprayed starting fluid in the intake... still nothin, its been sitting for over a year. but i thought compression, spark, fuel is all it needs all im getting it to do is hit one...
  3. stalling out after 10 minute ride

    ATV Repair and Maintenance
    Hi all! I just bought a 95 trail boss 250 2x4 2 stroke. It has been running well since i bought it. The starter isn't working so i have been pull starting it. About a week ago the rip cord tore and i retied it just as it was just shorter. But since i retied it the slack is...
  4. 03 Trail Boss

    Polaris Trail Boss
    Hey guys, I'm new to the site. But I'm needing help with finding a CDI Box for my bike. When I picked up this bike I didn't realize how expensive a new cdi would be (around 200 new). I haven't had any luck finding any used ones, so I'm hoping some of you can give me an idea where i can get a...
  5. Gearcase Compatability

    ATV Repair and Maintenance
    Can anyone tell me what gearcases are compatible with a 1994 Trail Boss 400L 6x6? I did some searching on the Polarisind.com pages, but the model # seems to only be used in other 4x4 1994 models and not in other years. Thanks.
  6. Need help, I'm stumped.

    Polaris Trail Boss
    Have a 1990 trail boss 250. Recently rebuilt top end. I'm trying to tune the carb now to get it to idle and run properly. First off it requires being pulled over about 7 times with the choke on full and the throttle wide open when it's cold. Then when it's running it will idle fine but I just...
  7. Recoil starter problem.....

    ATV Repair and Maintenance
    I have a 1988 Polaris trail boss 4x4 250cc and one day about 1 yr ago i went to start it up with the pull starter and the rope stayed out and didnt coil back in. This week i thought i should get back into it so I started to take it apart and I took off the chain covers, the chain and the first...
  8. 2011 Polaris Trail Boss 330

    2011
    The 2011 Polaris Trail Boss 330 ATV is the best value mid-size trail/utility ATV. It features Sportsman-like styling, 2-wheel drive and long-travel rear suspension. Key features are: •329cc Air/Oil Cooled Engine •Lock & Ride Racks •Automatic Transmission Features: Drive The Trail Bloss...
Top