Polaris ATV Forum banner

carborator

  1. Magnum 325 Starting Issues.

    ATV Repair and Maintenance
    I’ve recently gotten ahold of a Polaris Magnum 325. It need some minor repair. So what I have replaced is the starter, the starter relay. I bought those because they looked like in a poor condition. The relay had a bit of grime and some small rust on it. it. I also cleaned the gas lines to the...
  2. 2008 polaris 500ho carb problems

    ATV Repair and Maintenance
    alright im still having problems with my carb. aftermarket mods are 20 over bore wiseco racing piston clutch kit, stage 1 jet kit and a hot seat exhaust. it had a electric fuel pump that has been eliminated, the floats have been adjusted high, low, and now back to stock, the bottom of the carb...
  3. 98 400 Scrambler Carb issues, need solutions please

    Polaris Scrambler
    I have a 98 400 scrambler that I bought not too long ago and got running. I had to replace the gear case, swing arm bushings, rear end bearings, and the minor things like new plug, air filter, and fuel filter. I did away with the self mixing pump, took out the gear selector switch, and wired the...
  4. Polaris Trailboss 250 Won't Start

    ATV Repair and Maintenance
    Polaris 250 backfired and quit and won't start. seems to have compression but no suction on carborator.
  5. throttle frozen on carb.

    ATV Repair and Maintenance
    I have a 2001 scrambler that was sitting in garage for a couple years. Went to use it, the throttle was frozen. Worked great last time i ran it. I thought it might be the throttle cable,but cable was free when i took it off. That when i noticed that piece that the cable connects to inside carb...
  6. 03 sportsman 400 carb slide?

    ATV Performance Modifications
    ok i have been stumped on this for about six months now i have a carb issue or so i think, the slide isnt coming up when i punch it and obviously no power unless i pick it up with a screwdriver, i have went through everything from rebuilding the engine up to the diaphragm in the carb dose anyone...
  7. Common Carb Issues

    ATV Repair and Maintenance
    Just trying to get a list of common carb issues for a 2002 TB. From what I was able to get from the parts guy from the dealer was the following. - The needle and seat was a common part to wear out which hinders the carbs ability to prevent fuel from back-flowing out and getting into the air...
  8. Common Carb Issues

    Polaris Trail Blazer
    Just trying to get a list of common carb issues for a 2002 TB. From what I was able to get from the parts guy from the dealer was the following. - The needle and seat was a common part to wear out which hinders the carbs ability to prevent fuel from back-flowing out and getting into the air...
Top