Polaris ATV Forum banner

electical problem

  1. 2016 Sportsman 450 Electrical issues

    ATV Repair and Maintenance
    Hello, I am new so thank you for your patience. I have a 2016 Sportsman 450 that won't crank. When I turn the key over nothing happens, no clicking, no cranking, no nothing. But with the key in the run position or on position, when I jump the starter solenoid it starts fine and runs perfectly...
  2. 2006 sportsman 500 HO misfiring

    Polaris Sportsman
    So I'm new to this whole forum thing, and hope I'm posting this in the right place... Anyway, I bought a 2006 sportsman 500 HO of a friend of mine this past spring and I've loved it so far. So I've started to put some time and money into it. I installed an EPI clutch kit, K&N filter and a DG...
  3. 05 700efi electrical issue sitting duck.

    Polaris Sportsman
    Hello everyone. I am having issues with my quad. 05 700 twin efi. I was using the winch one afternoon and the battery light flashed on the gauge. So I stopped using winch. Revved up a lil bit and then died. No power. Battery tested good. Stripped down and inspected wires etc. my fuse block on...
  4. Polaris 2004 400 No Power to Anything!!!!!!!!!!!

    ATV Repair and Maintenance
    Hey guys! im new to the forums. so im gonna get right into the question. I have a polaris 400 2004 that has been torn down (im 16 and dont know much about mechanics) and it recently would not start! no power to anything not even lights. it will pull start but it wont start because the rip cord...
  5. 1992 350l 4X4 STRUT WIRE ISSUE

    ATV Repair and Maintenance
    Hello, I am new to the forum, I joined as I always found my self going to this forum for answers but I have a problem I cannot find a solution to yet. I have a 1992 Polaris trail boss 350l and the wire that goes into the strut has broken right were it enters the strut. I would like to know if...
  6. 05 Sporty 400 Stator--Again

    ATV Repair and Maintenance
    So my 2005 Sportsman 400 ate it's second stator so far in the time that I have owned it. Battery light started blinking on me and slowly got worse and worse until it would blink at idle. Checked the three charging legs with a multi-meter and all 3 had continuity to ground. Anyone know if these...
  7. 1991 trail boss has no spark,Really Stumped here

    Polaris Trail Boss
    hey guys,I need help im stumped,got a basket case trail boss and started working on the electrical system.When I got it they had it wired to run with no battery and starter and silonoid was bad.I replaced the starter and silonoid,that works,new battery,new coil,tried my cdi off my working...
  8. Short circuit

    Polaris Phoenix
    Evening all: My son has a 2007 Phoenix and loves it. But it's developed a problem. We have an electrical short circuit somewhere, and I'm horrible with electrical. At this point it blows the main fuse (when replaced) without the key even being in. I looked through the manual, and nothing that I...
  9. Starter noise

    Polaris Sportsman
    I have my 99 sportsman 500, when i try to start it either the starter won't engage and will just make a grinding noise, or it will engage and start the motor and then will make that same grinding noise for about 4-5 seconds after starting. I have no idea what this could be. I had a friend look...
  10. No electric start

    Polaris Sportsman
    Guys, i am new to the site but have a problem that needs fix'en! 2002 Sprotsman 500......wont electric start. recently put new battery in tail lights and headlights work well[no flickering ect] will pull start relitively easily. will electircally start occasionally....very occasionally! i...
Top