Polaris ATV Forum banner

magneto

  1. Polaris Sportsman Flywheel help..

    ATV General Discussion
    I got a new flywheel for my 02 sportsman 700 because my magnets came out. The new flywheel is one from the ac to dc upgrade kit. The flywheel I got hit the stator bolts. Can I get a new stator for that flywheel and splice the wires? Or where can I find the new clip in magnets? thanks in advance
  2. can i make a stator from an 07 work on my 2001 both scrambler 500

    ATV General Discussion
    pulled my motor from a 2007 and was gonna put it on my 2001. problem is is there are different clips and amount of wires. I no longer have the 07 so cannot get the wiring harness from it. can I make this one work somehow? will the bike run without the stator? thanks for any help.
  3. 1990 Trail Boss 250 2x4 Breaker Trips Continuously

    ATV Repair and Maintenance
    I recently bought a 1990 Trail Boss 250 2x4 for my wife. It ran great at the test drive. Suddenly, now that i have it home, as soon as the key is turned on, the breaker trips and kills the power. It cycles as it's supposed to, and trips immediately. I tested it by replacing it with a 10a...
  4. flywheel magneto problems

    Polaris Trail Blazer
    Ok. I just bought an 04 trailblazer. They said the motor was locked up so I got it CHEAP. turns out that it wasn't locked up. The magnets in the flywheel were shattered and the stator unit destroyed. I replaced the parts and got it run with ease. Road it up the block and back a couple times...
  5. My battery keeps going dead

    Polaris Sportsman
    2001 Sportsman 400. My battery keeps going dead. I just put in a new battery. Everything seemed great for about two weeks with the new battery, but now it's dead like my old one. The starter hasn't worked for a few years, you can feel a "click" when you try to start it with the key (when...
  6. Stator swap...

    ATV Repair and Maintenance
    I am trying to find a stator for a 1985 trailboss 250 and have found a stator for a 1998 trailboss 250. Can I use the 1998 for the 1985? I know that the connectors are opposite but the wire colors are the same and the only other difference is the single trapazoidal shaped coil is a one piece on...
  7. 03 Sportsmam 600 Did an ignition/stator kit, now see statr on digital display

    ATV Repair and Maintenance
    Took bike from CA to CO for elk, ran normal/perferct. Parked for 10 days, reloaded and back to CO for deer. Bike sat uncovered in a snow storm but that wasn't unusual. But, it didn't start when we got to camp. As best I could tell there was intermittent spark. Tried all the easy stuff. It was...
Top