Polaris ATV Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 73 Results
  1. ATV Repair and Maintenance
    Hello, My low headlights started to cut out and with them my spark, everything apart that seems to be fine my high headlights still work and the starter works. Where should i start to check for problems?
  2. Polaris Predator
    What is going on everyone.. I have seen post after post about this same issue, but figured I will give it a shot posting a new one as the other ones were from years ago... I recently picked up a 2005 Predator 50.. Was told it was running last year but was put away and now does not start.. I...
  3. ATV Repair and Maintenance
    Hello I’ve heard that cams can slip on their gear, what should i do to prevent that, could i weld the gear to the cam?
  4. ATV New Members
    HEY EVERYONE I AM NEW TO THE FORUM. I TRYIED A DIFFERNT FORUM THE OTHER DAY AND CANT SEEM TO GET ANY REPLIES.. ANYWAY.... I HAVE A 2003 POLARIS PREDATOR 90CC AND I AM TRYING TO FIGURE OUT WHERE AND HOW THE LEFT HAND SWITCH (STARTER/KILLSWITCH) GROUNDS... DOES ANYONE KNOW HOW THAT SWITCH GROUNDS...
  5. Polaris Predator
    Hi from Finland I bought a predator 500 tld with two broken engines, both have transmission broken(transmissions are not the same). I was thinking of repairing a less broken engine and I found out which part is broken. ( 4th Gear 3089634 ) But the next problem became finding a new part, the...
  6. Polaris Predator
    This last weekend I rebuilt my carb and removed the factory airbox and replaced with an uni filter directly attached the carb. I left the breather hose coming from the crankcase just hanging out back. Everything started up and idled fine but as soon as I gave it any throttle a LOT of oil...
  7. ATV General Discussion
    It’s a 2004 predator 500. Sent the cylinder off to have it bored and sleeved over to a 560cc since the original rebuild I have torn it apart about 7 times and replaced the head gasket referencing different websites and the owners manual for torque specs. Everytime I rebuild it it seems to run...
  8. ATV Repair and Maintenance
    I got a 2006 Polaris predator 500 and it was amazing never really had to do anything to it, just oil changes and put gas in it, but now the cold as came in and it won’t start, it’s getting Gas and spark, the carb is not clogged and I just did the oil and filter on top of a new air filter, I...
  9. Polaris Predator
    Hello I'm looking to buy a good condition or new pure Polaris pipe for my 06 predator 500. Let me know if you have one.
  10. Polaris Predator
    Hello. I recently purchased a polaris predator 500. The day after bringing it home I went to start it and it wouldn’t start and would barely crank. The next day it no longer cranked at all. It will bump start/pop start, but will not crank at all from the electric start. Installed a new battery...
  11. ATV Repair and Maintenance
    I have a 2005 Polaris Predator 500 and I'm assembling the top-end and just noticed that I'm missing one of the guides that goes on top of the bearing on the camshaft that sits between the camshaft bearing and a camshaft cover. Does anyone know what this part is called or if it can be purchased...
  12. ATV General Discussion
    Need some help, when i start my atv i press the throttle and it revs high for like 5 - 10 seconds after letting off the throttle, also even after its warmed up it will die on me randomly, i tried adjusting the idle screw but that didnt help.
  13. Polaris Predator
    I picked up a 2003 predator about a week ago, it was a little rugged but seemed to run alright. So i take it for a test ride, i'm not beating it or anything, it seems good so i take it. later when i get home i ride it again and i notice when i try to ride it hard it doesn't have much power...
  14. ATV Repair and Maintenance
    I week ago I bought a 2006 predator 500. I ran it for about 3 hours then went to start it it started up fine but bogged out about 1 minute later. Tried to start it back up and would only start with choke on. After that I found out that the battery cables were loose. Long story short I had to buy...
  15. ATV New Members
    New to this site. I just acquired two identical 2005 Predator 50 cc machines for my twin grandsons. They haven't been started for 4 years and I am about to dive into them. I am in search of a maintenance manual. Any help would be greatly appreciated!
  16. ATV Wheels & Tires
    I've bn doin a bunch of reading and people seem to either really like the gbc or say they wear extremely quick. For nearly half the price I would be OK with a lil quicker wear then the razrs. My razrs are the original from 05 an r bald on tops in a bad way. So I don't mind paying the extra money...
  17. Polaris Outlaw
    Hey everyone I'm a new member to this site. I've been using these forums for a while now and I've been trying to figure out why I can't get my outlaw to run nicely since I put a pipe and intake and jets in. I ordered the HMF borich slip on with a foam umi clamp on filter and HMF jet kit and...
  18. Polaris Predator
    My 2005 predator 500 was barely starting and if It did would run rough. After looking into it I realized it was a bad fuel pump and disconnected the lines and ran a line from the tank straight to the carb to get me by for now. The quad ran great for hours with no issues. Is there any need to...
  19. ATV Repair and Maintenance
    Hey guys. Im new here to the forum and was hoping to gain some incite and helpful information from here. I recently picked up an 03 pred 500 that a guy had ordered all the part to redo the top end and never put it back together. Ive got a service manual and am planning to put it back together...
  20. Polaris Predator
    I have a 2005 predator and it all of a sudden won't start. I can push/pull start it but my starter solenoid keeps clicking. I put a new solenoid in it and it still keeps clicking. Once in a great while it will barely turn over. HELP????
1-20 of 73 Results
Top