Polaris ATV Forum banner
ranger
1-19 of 21 Results
  1. ATV Repair and Maintenance
    Trying to start a 2009 polaris ranger and the wrench icon flashes on the dash. Vehicle wont start...If I try and start it in neutral, the wrench icon does not appear but it still won't start. The Ranger got warmer than normal the other day but still drove fine for an hour after. Wont start back...
  2. ATV General Discussion
    There’s a 2003 Polaris Ranger 500 6x6 for sale near me for $4,500. It has 730 hrs, unsure of the miles. I in no way need to buy this, and I’m only slightly considering it. I wanted to ask if any ranger 6x6 owners or 6x6 owners in general have any input on common problems, general maintenance...
  3. ATV Repair and Maintenance
    Hello everyone, new to the forum here. Just got a 2016 Ranger 570 in the shop for a valve job. not starting. Got in there and all valves were in spec other than one of the exhaust valves which was at .017 which is the furthest out of spec ive seen on an engine this new. any idea what would cause...
  4. ATV New Members
    I am looking to swap my 16 Ranger rim and tires onto my 02 Sportsman and pick up a new set of rims and tires for the Ranger. The Sportsman has 12" rims in the front 10" in the rear, where the Ranger has 12" all the way around. I read Polaris requires a 1" tire diameter difference front to...
  5. ATV Repair and Maintenance
    Hi guys, The voltage regulator and the battery melted while driving. I replaced those but I'm still not getting power to the fuel pump. Any suggestions? Thanks in advance for any help!
  6. ATV Repair and Maintenance
    Hi guys, The voltage regulator and the battery melted while driving. I replaced those but I'm still not getting power to the fuel pump. Any suggestions? Thanks in advance for any help!
  7. ATV Repair and Maintenance
    We have a 4x4 Ranger with rough idle, and the service manual recommends a leak-down test. However, there's no guidance on how to find top-dead-center. Bumping the starter and inserting something in the spark plug opening is inconclusive, as it seems like the rotation always lands at the same...
  8. ATV Repair and Maintenance
    Hi and thanks for reading. Any al all help will be greatly appreciated. My Ranger 700 EFI runs but not well. When this started I trouble shot through and repaired several issues each time thinking I had solved it but to no avail. Fuel pressure was lower than acceptable range so pump was...
  9. ATV New Members
    My new $12,000 UTV has been recalled. It is unsafe. The heat shield was improperly engineered and caused fires. Out of the goodness of their hearts Polaris will repair the UTV (I wonder if they volunteered or were afraid of lawsuits???). Unfortunately I had to pay to have the UTV delivered when...
  10. nFLOW Motorsports
    nFlow offers complete remanufactured Polaris Ranger/Sportsman 700 crate engines! Engine are assembled with precision, using stringent operating procedures. Include: New pistons, ring sets, valve train, cam chains, oil pump chain, idler chain, mechanical seal, valve seats, crankshaft, bearings...
  11. nFLOW Motorsports
    nFlow offers complete remanufactured Polaris Ranger/RZR/Sportsman 570 crate engines! Engine are assembled with precision, using stringent operating procedures. Include: New pistons, ring sets, valve train, cam chains, oil pump chain, idler chain, mechanical seal, valve seats, crankshaft...
  12. ATV Wheels & Tires
    I see a set of tires that are off a 2013 Ranger for sale and I would like to replace my dryrot tires. I see my original tires and rims call for 25x8-12 on the front. If these tires (25x10-12) from the Ranger have the same lugnut spacing (I think they do?) could I put the wider tires on front...
  13. ATV New Members
    I was sure that I would find low or no charge voltage, but it's at 14.4 with lights on and cutting out in mid range rpm, the radiator fan doesn't seem to effect it to much. idle voltage is about 14.2. Disconnected, the Yellow stator wires to ground are open and yellows are each putting out 9.8v...
  14. ATV New Members
    Hey there. New to the site. I recently bought a used 07 Ranger XP700. It has 6K miles, and about 500 hours. Had a dealer look it over, change front and rear diffs, transmission oil, engine oil, new oil filter, new belt. They said it looks great, and that these machines will go forever, they see...
  15. ATV Repair and Maintenance
    Our Ranger moves only when we have the differential locked and AWD on. Not sure what can be wrong, any suggestions?
  16. ATV General Discussion
    Just wanted to show off my latest project. Let me know what you guys think.
  17. ATV Purchasing and Price
    What would you consider a decent price for a 2011 Ranger Crew 800 eps? My local dealer quoted me $20,935 otd (w/ a few goodies, of course). To be specific, I have $6,935 worth of extras. He listed MSRP for all items and gave me free labor. Am I being cheated, or is that a fair deal?
  18. ATV New Members
    Hello all. I'm hoping somebody can provide assistance with an older (2003) Polaris Ranger Series 11. It's had a history of being difficult to start (especially after sitting for a while). Usually, if I replace the spark plug & fiddle with the choke, it will eventually start. This time, that...
  19. ATV New Members
    I have a 1999 Ranger 6x6 that will only crank once then the starter keeps running. If I try 20 or so times, it will eventually fire up. Not sure how to diagnose if this is a starter or what. New to the board, so let me know if i need to post elsewhere. Thanks!
1-19 of 21 Results
Top