Polaris ATV Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-19 of 500 Results
  1. ATV Repair and Maintenance
    Over the winter I parked my ATV outside, where it seemed to have been it's whole life before I owned it. Went out a week ago to take it for a spin and the dash was dead, nothing indicated on it. The ATV started and ran like normal, just nothing on the gauges. Is there a component that will...
  2. ATV Repair and Maintenance
    I have a polaris sportsman 90 that is annoying me. It has spark starts up, dies seconds later and then i;m stuck with no spark again. When I have spark its perfect and strong blue in color. No noticable wires with damage. All help is appreciated. Thank you, Alex
  3. Polaris Sportsman
    This atv is a project of mine that ive meen wanting to get running. Ive replace the carb and im getting good fuel flow now, replaced the fuel lines, pump, and shut off valve. Ive checked compression with my thumb in the spark plug hole and it feels like it has good compression, ive put an nkg...
  4. ATV General Discussion
    Hi all, thank you for your help in advance with this issue! This is been driving me quite nuts. I have a 2016 Polaris sportsman 450. About 2 weeks ago we noticed the machine was sputtering about 1/2 time it was ridden. We also noticed that it would randomly electronically shift between 2x4 &...
  5. Polaris Sportsman
    ATV: 2024 Sportsman 570 Trails less than 100 miles. Story: Cruising through riverbed with super soft muddy surface I attempted to cross and it was shallow, I could see the bottom, instantly sank to skid plate submersing ATV up to the seat. I haven’t ridden a quad in a very long time and didn’t...
  6. ATV Repair and Maintenance
    I am stumped by the carb leak issue I am having. The carb on my 2011 Sportsman 500 started leaking from the drain/overflow at the bottom, but it only leaks when the engine is running with some throttle. It does not leak at idle or when the engine is off. I checked the drain screw and it was...
  7. ATV Repair and Maintenance
    Just replaced the main clutch assembly due to severe wear on the dogs. Belt too. Runs better, but still won't advance into the higher range. Raps out at about 20 - 25mph in high. What am I missing? Do I need to Lube the clutch? Is there something in the rear shiv? The rear one spins awfully...
  8. Polaris Sportsman
    I have a 2020 Polaris 570 and had it into the shop they said it was leaking oil so I took it to warm up to change oil and it lost the drain plug and shut off on me. Please someone tell me if there is an oil safety switch or some advice on what to do. The company is trying to say it is not their...
  9. Polaris Sportsman
    I appologize if this has been answered elsewhere, but in all the research i've done I can't find it written and i'm beating my head against the wall on this one. 2007 Sportsman 500 EFI. Runs and drives great, but battery light and speedo needle immediately start to flash the second the key is...
  10. ATV Repair and Maintenance
    We put in a new axel on the left rear (non-brake side) of our Sportsman 500 and the hub has too much play vs the amount of play for the old axel. To clarify we are not talking about the play the axel has, but qhere the hub connected to the axel has a little bit of play (wobble) ... this gets...
  11. ATV Repair and Maintenance
    Hi all, I have been working on on my own four wheelers since 13 years old, and never had to resort to posting on a forum until today. I only tell you that so thats so you all know how stumped I am. Here's the situation... My dad drove my 2019 Polaris Sportsman 850 SP through a ton of brush...
  12. ATV Repair and Maintenance
    Looking to swap engines, here’s a little introduction. Picked up a flawless condition 1989 Sportsman 400. Got it knowing the little 2 stroke was hurting, and before I got a chance to rebuild it the skirt of the piston wore thin, it peeled off then fell down between the crank and the case...
  13. ATV Repair and Maintenance
    Hey folks, I have a 2002 polaris sportsman 500 HO and need a pic of how the ignition coil was hooked up. I have a haynes manual, wiring diagram and searched all over for just a pic of it hooked up in the bike. if someone could help me out that'd be deadly. thank ya kindly!
  14. Polaris Sportsman
    Hey, another silly question but the gauge pod/cluster on my bike was cracked from the previous owner and has never worked due to moisture. But know im doing more demanding rideing so I need 4wd which doesn't work without the gauge (silly polaris things) and I'm having trouble finding one now I...
  15. ATV Repair and Maintenance
    Hello, this is my first post and I am lost on what to look for with my four wheeler. It is a 2018 polaris sportsman 450 HO Utility Edition. Unit has 24 hours on it, at 23.4 hours, the engine was rebuilt, due to engine lock up from oil leaking out at engine from the oil filter. It didn't get...
  16. Polaris Sportsman 570
    Hi folks. Recently bought a 2015 Sportsman 570 Touring. Condition is very good, looks like a newer machine. Have probably put an hour on it. I used it for some work around the yard on Sunday, and was sitting idling about to go for a ride when the engine stopped and the check engine light came...
  17. ATV General Discussion
    Hello, I’ve been trying to find a clutch cap for my 2009 Sportsman 800 EFI X2 and had no luck. I purchased a clutch cap that looked almost identical to mine and it didn’t fit. how safe is it to drive with a broken clutch cap? Part # 1322749
  18. ATV Repair and Maintenance
    Hello, I have a 2009 Polaris Sportsman 800 efi and I need to replace the primary clutch cap (I had it broken). Can I purchase a different clutch with different part number and take the cap of (pic below)? The part number on my primary clutch is 1322749
  19. ATV Repair and Maintenance
    Hello my bike was in a garage getting fixed, changed piston, clutch and other stuff and it finished 2 days ago and when I started it i got this sound and I don't Know what's causing it, please let me know what's wrong and how to fix. Thanks
1-19 of 500 Results
Top