Polaris ATV Forum banner
tranny
1-7 of 7 Results
  1. ATV Repair and Maintenance
    Hello , I am facing a problem with my 01 Sportsman 500 6x6. It makes a squealing noise in high gear () I changed the belts and adjusted the scondary clutch washers with no improvement. The noise only happens when in high gear and when torque is applied. The ATV does not make noise when it runs...
  2. Polaris Sportsman
    The roll pin on the rear yoke dug a hole in my transmission and filled it with muddy water. I didn't even realize it 'til it started whining. Well I repaired the case and replaced every single bearing in it, but there's still some whining in high. Kind of like the whine from a worn out rear...
  3. Polaris Scrambler
    hello every one im writing this because iv been reading about the tranny swap and how big of tires you can run do you need it don't you need it and so forth so here is my to cents i have a 2000 500 scrambler with 26 inch swamplites on the front and 25 inch on the back all i did was put an epi...
  4. Polaris Sportsman
    hey guys i got my quad ive been fixing her up all the time it feels like then as fate has it im not doneive fixed the front end starter battery and a full tune up all the way around the quad its been seriously aggervating but besides that i enjoy doing it but this problem is bugging me now cause...
  5. ATV Repair and Maintenance
    so we think the tranny is out on our 96 trailblazer. my husband has only started to tear into it. he initially thought it was the front sprocket that was bad causing the chain to slip but once he got going he now thinks its something with the transmission. as far as i know he hasnt pulled the...
  6. ATV Repair and Maintenance
    Hey I am new to the ATV scene, about to get a 04' 500 Sportsman. The deal is "locked" I guess, gonna pick up a 500 Sportsman within the next week. The motor has low hours since last rebuild, runs great, but the owner says it has "rearend" problems and he can't figure it out. I'm trading a Honda...
  7. ATV Repair and Maintenance
    Hi Everyone. I spray washed (at the dollar car wash place) my 2006 Polaris Sawtooth to get the mud off. It was working perfectly BEFORE I washed it, now the tranny acts like its slipping. No forward movement, and very weak backwards (reverse) at full throttle. What's the problem? I hope its...
1-7 of 7 Results
Top