Search Results for ‘wiring harness’

Hi all, Bought a used 2007 sportsman 700 EFI about 2 years ago and ever since I had it, it has been producing the same problem but getting worse over time. I have tried everything i can think of to resolve it. The quad used to generally start up fine but if i let it get too warm and idle then...

I recently bought a used 1998 Sportsman 500 4x4 and it only had 1,500 miles on it. Ran beautifully until today. I installed a winch on it yesterday and ran it for a while. Today, I went to start it and everything was normal. Rode around for a little bit and it shut off. I went to start it and it...

Hi, new to the forum. I've searched the ole intewebs and have come down to asking for assistance on my sportsman 90. So a bit of the backstory is that the carb bowl drain screw leaked and caused a fuel fire on the machine. It got put out fairly quickly but not till after melting the fuel line...

I could really use your help. I have a 2009 Sportsman 500 X2 ATV with EFI. Last night while hauling the trash up my long driveway, I started having a problem. When I turned to the right, all power died and killed the engine. I turned left and the power was back on and I could restart the...

I'm having trouble with my 2012 550xp two up. When the bike comes under strain either pulling someone out of the mud or slowly crawling over a larger obstacle the bike will go into safe mode and I will loose power steering and the engine light and temp light will come on. If I stop and put the...

I'm trying to find out if I can replace the plastic connector from the wiring harness to the throttle assembly on my 2007 polaris sportsman 800 without out buying a new harness. Thanks for the help

2002 - Predator 500 SE Hello All - Made a dumb mistake this weekend of hooking up the jumper cables backwards on my Predator. Almost immediately it started smoking, melted a few wires on the harness and something sizzled and then popped. The engine still turns over but won’t start. Really...

Hello Friends, Spent the weekend installing a Badlands 2000lbs. winch. All hooked up except one thin gauge red wire that runs from the winch control switch to the ignition switch. It is supposed to be connected in to the ignition as a safety features that prevents the winch from operating...

I purchased a new 2009 Sportsman 800 X-2 in April of 2011 from a dealer in Northern Saskatchewan. I use it primarily as a yard machine out on our acreage. It has never been in the mud or on any rough trails. Last week with 79 hrs and 214 miles on it, it wouldn't start. Brought it to my local...