Polaris ATV Forum banner

wiring

  1. 2004 Sportsman 500 Solenoid Wiring

    ATV Repair and Maintenance
    Hello - I am trying to replace a solenoid in my 2004 Sportsman 500. It has 4 posts like the old one I replaced. I, of course, didn't take a picture of how it was wired before taking it apart. There are 4 posts on the solenoid. I believe I have the two smaller posts on the left (in the pic) wired...
  2. 2004.5 taillight help

    Polaris Sportsman
    Before I ask, I'm sure this has been beat up but I cannot find my answer after much searching. I have a 2004.5 500HO with a 1157 taillight lamp. I'm trying to save some power for accessories by changing it to LED. I tried a simple replacement 1157 LED lamp but it isn't working. Do I need a...
  3. Headlight issue need lead in right direction

    ATV Repair and Maintenance
    Hey guys I own a 2013 Polaris sportsman 500 ho and the other day I notice that my low beem light was dead I was going to swap it out but notice that the wires are apart and the plug is still in the socket with wires on them the green and brown I believe so I'm wondering if you can buy the wire...
  4. CDI and harness wiring 500 HO Sportsman 2007 Carb

    Polaris Sportsman
    Apparently not even t e Clymer manual has a wiring diagram for the 2007 500 Sportsman HO Carb. You can look at it online and it shows up to 2006 and then again from 2008-2013. Unreal. I'm done asking for wiring diagrams. Nobody seems to have one. When I get mine running I'll hopefully make my...
  5. 2014 Sportsman 400 HO Winch

    ATV General Discussion
    Is the 2014 Sportsman 400 HO pré wired for a winch? If it is how much wiring is involved?
  6. Wiring of High Beam on 2008 Sportsman

    ATV Repair and Maintenance
    Hey, New to this forum even though I have used it many times searching for threads for my ATVs. Thank you! My question. I have a 2008 Polaris Sportsman 800 Touring EFI that the high beam light stopped working. I have pulled all the plastic and casing off to see inside easily. I pulled the...
  7. 05 sportsman 700 Wiring question for AWD

    ATV Repair and Maintenance
    Hello been working on this project for a bout 3 weeks in spare time. Awd isn't engaging on my ATV. I have power to grey wire that feeds into the hub coil connecter, located under the instrument cluster. I only have power to this wire when the AWD switch is on AWD. it goes out when switched to...
  8. Looking for unswitched 12 volts on 850

    Polaris Sportsman
    Fuse box on my 850 shows a 10 amp unswitched fuse. Where does it lead to? Where is the connector so I can power my GPS unit that will have its own on/off switch? Need live a power source and fuse box seems to indicate it is available up front rather than me running a wire from the battery...
  9. Winch was wired so that it's always got power...

    Polaris XP
    The Polaris dealer wired my Superwinch Terra 35 winch so that it's always got power. Even with the red switch on the handle bar set to STOP or OFF or whatever it says. Is that bad?
  10. Winch Installation 2013 Sportsman 400

    Polaris Sportsman
    I recently purchased a Polaris 2013 Sportsman 400 HO and purchased a kit of the 2500 LB winch to install. First thing I noticed was that the instructions were for several ATVs 400 HO, 500 HO, 800, 6X6, International. So, this gives one reason to doubt that all you need to know will be...
  11. Relay / Battery Hook Up Question

    ATV Repair and Maintenance
    putting in a new harness because the previous owner modified the old harness so bad. any help - as ALWAYS, is very appreciated... :) any wires not there that should be? what goes where?
  12. Cargo box LED brake/running lights... HELP!

    ATV Visual & Body Modifications
    I bought a Tamarack Titan Series Deluxe Lounger and a set of rear fender guards/foot pegs (all from Thor) for my 2012 Sportsman 500 HO. Everything looks great and my wife really likes the setup. I was a little bummed I couldn’t find a box to fit with the OEM rear rack extender installed, but...
  13. Wiring From Factory 2012 800

    Polaris Sportsman
    Hello, I picked up a Sportsman 800 and one of the first things I did was the 3 headlight relay mod. Very nice - thanks forum. The more I go through this machine the more I see wires that are not terminated. Looks like wires for a winch, maybe heated grips, etc...but I'm not sure. Does...
  14. 2006 Sportman 500 display problem

    ATV Repair and Maintenance
    Ok I fried my left hand control module for my lights, run switch, and reverse override. I replaced it and my lights started working after about a minute I started to smell over heated wires. I turned the key off and looked for the problem found that my front differential (can't remember the...
  15. Strobes

    ATV General Discussion
    http://www.amazon.com/Wolo-8004-1CCCC-Hideaway-80-Watt-Supply/dp/B0036FJ804/ref=sr_1_7?ie=UTF8&qid=1325720240&sr=8-7 Do you guys think that these would work in a 2008 Polaris Sportsman 500? I have heard that these hide-a-way strobes can melt the headlights. Also, would you wire this right to...
  16. 2009 400H.O. Battery wiring

    ATV Repair and Maintenance
    It took me a while to get a replacement battery here in Alaska and I installed the new one (anyone who has one of these knows how that goes) and now I don't have power to the ignition/instruments, but my lights work. What did I leave out of the hook up? I have a large and small wire connection...
  17. Wireing my Regulator

    ATV Repair and Maintenance
    I was trying to find out why my battery was having issues charging and discovered I was missing my voltage regulator. It had been taken for parts I suppose from the shop I bought it from. Does anyone know where the five wires go to in the system. My Sportsman 700 shop manual doesn't go into...
  18. scrambler 400 intermittent loss of spark

    ATV Repair and Maintenance
    replaced coil, has no spark, then randomly gets it back and keeps it til i put plug in and try to start and pull it back out and no spark again anyone know whats wrong?
  19. 2004 700 can't read RPM on cluster

    ATV Repair and Maintenance
    I purchased this roll over and I'm trying to get it back to riding condition. We are almost there. I had to purchase a new cluster for it and I'm not seeing the RPMs on the display. The gears and four wheel drive indicators work fine. Basically everything concerning the yellow info button on the...
  20. 1998 Sportsman 500 4x4 Wiring

    ATV Repair and Maintenance
    I just bought a 98 500 Sportsman a day ago and I took it out and can't get the front wheels to pull. The axle shafts spin to the hubs, there is resistance in the coils (reading taken at the rats nest under the hood-like cover). It also draws about .34 amps when jumpered with a known hot...
Top